Home | Community | Message Board


This site includes paid links. Please support our sponsors.


Welcome to the Shroomery Message Board! You are experiencing a small sample of what the site has to offer. Please login or register to post messages and view our exclusive members-only content. You'll gain access to additional forums, file attachments, board customizations, encrypted private messages, and much more!

Shop: North Spore Cultivation Supplies   Kraken Kratom Red Vein Kratom   PhytoExtractum Maeng Da Thai Kratom Leaf Powder   Left Coast Kratom Buy Kratom Extract

Jump to first unread post Pages: 1 | 2 | Next >  [ show all ]
InvisiblePiptheGreAtest
Aspiring Heavyweight
I'm a teapot User Gallery

Registered: 07/18/16
Posts: 464
DIY Dehydrator setup * 1
    #26579532 - 04/05/20 01:29 PM (3 years, 10 months ago)

So I’ve decide to build my own dehydrator because I feel most available are to small for my liking plus I need a project during this bullshit lockdown. So i got a general design using plywood, 2x4 or some type of lumber, I plan on having 5ft tall 2.5 wide and 2.5 deep with about 20 screen trays around the same dimensions. I putting a heating fan at top about 1500watt and some thermometers so I make sure I’m getting even drying. Few questions here how hot is too hot to denature the active ingredients, along same line do you think I’ll need 2 of the heaters to reach the correct temps? Will I need a fan for correct circulation and do I need Exhaust holes in the bottom? Appreciate the advice.


--------------------


Extras: Filter Print Post Top
Invisiblefilthyknees
no coincidence
 User Gallery

Registered: 03/08/13
Posts: 6,283
Trusted Cultivator
Re: DIY Dehydrator setup [Re: PiptheGreAtest]
    #26579647 - 04/05/20 02:32 PM (3 years, 10 months ago)

Hey pip,

How much exhaust and heat you need depends on your space, it won't be that hard to do. Gonna have to test it ultimately, - I used a bag of apples cut up before drying cubes (throw a lot of banana on there too.. for testing purposes).
For similar dimentions I used 2 1500w heaters, from the bottom, and a boxfan on low in the middle.

The exhaust is passive (think of a traditional common dehydrator). Anything above 100 will work, definitely no need to go above 160.

Also something to note, mine was located in an open air garage, in the winter and fall it worked fine but with the high humidity of summer I had to invest in another Cabela's because the fans where blowing air in with such a water content the mushrooms had no way to dry. Barring the high humidity environment sinario it worked well.

Based on madhatter420s build

Details here https://www.shroomery.org/forums/showflat.php/Number/25824371


--------------------
But if you're in a hurry, and really got to go
If you're in a hurry, might have to find out slow
That it's one thing to try and another to fly
You get there quicker just a step at a time
It's one thing to bark, another to bite
The show ain't over till you pack up at night


Extras: Filter Print Post Top
OfflineStromriderM
This must be the place
Male User Gallery


Registered: 06/02/13
Posts: 7,336
Loc: Dept of know what I'm say... Flag
Last seen: 11 hours, 34 minutes
Trusted Cultivator
Re: DIY Dehydrator setup [Re: filthyknees] * 1
    #26579675 - 04/05/20 02:46 PM (3 years, 10 months ago)

Id definitely put the heat in the bottom and the exhaust out the top. Don't swim up stream. Heat wants to rise. I know filthyknees has had success with his build. That's the guys brain to pick on this. I just go buy cabelas 160 liter dehydrators because I'm doing my part to help the economy :grin:
Eternal consumption engine 💲💲💲


Extras: Filter Print Post Top
Onlinerumfor69
Bodhicitta Cultivator
Male


Registered: 08/05/11
Posts: 6,843
Loc: In the Gills
Last seen: 9 minutes, 24 seconds
Re: DIY Dehydrator setup [Re: Stromrider]
    #26579700 - 04/05/20 02:59 PM (3 years, 10 months ago)

What's the warranty and life length of those Cabelas dehydrators and
are they fairly quiet?


--------------------

Links For Beginners And Beyond:mspoil:


Extras: Filter Print Post Top
Invisiblefilthyknees
no coincidence
 User Gallery

Registered: 03/08/13
Posts: 6,283
Trusted Cultivator
Re: DIY Dehydrator setup [Re: Stromrider]
    #26579712 - 04/05/20 03:02 PM (3 years, 10 months ago)

That's the advice I would give my former self - 160L commercial ones.

Had one crap out on me yesterday, the switch went bad after nine months(?), I almost shit.

Got a 5in1 tool and popped the switch mechanism into working steadily again.

If you have the space to work with a 2.5ft tray of cubes then I would lean towards reccomending the commercial models but if the principles are there have at it.

@rumford: there's some humming and whirlling, it's not outrageous but you'll know it's there if you're standing by it (same as any big dehydrator). Idk any warranty info.

Also another thing to note is the diy will require you to rotate the trays downward, the bottom trays dry faster. - this is rarely the case with the commercial models except when overly stuffed.

I expect good things pip.


--------------------
But if you're in a hurry, and really got to go
If you're in a hurry, might have to find out slow
That it's one thing to try and another to fly
You get there quicker just a step at a time
It's one thing to bark, another to bite
The show ain't over till you pack up at night


Extras: Filter Print Post Top
InvisibleSmartattack
C'mon man
 User Gallery


Registered: 12/21/18
Posts: 3,776
Loc: A thought
Trusted Cultivator
Re: DIY Dehydrator setup [Re: filthyknees]
    #26579725 - 04/05/20 03:08 PM (3 years, 10 months ago)

I'm willing to bet a Nesco gardenmaster will continue to be effective with 20+ add on trays. My experience with mine is that it's a monster in sheep's clothing. I know this doesn't help you diy anything. :shrug:


--------------------
* Smarts videos :teacher:
* :thumbup: Planet of the APES:thumbup:
 
I'm a fungal white supremacist.


Extras: Filter Print Post Top
Invisiblefilthyknees
no coincidence
 User Gallery

Registered: 03/08/13
Posts: 6,283
Trusted Cultivator
Re: DIY Dehydrator setup [Re: Smartattack]
    #26579735 - 04/05/20 03:14 PM (3 years, 10 months ago)

He's probably doing more than 2.5x 20 trays in a nesco with the dimentions he mentions.

I still love my american harvest, different beasts though.


--------------------
But if you're in a hurry, and really got to go
If you're in a hurry, might have to find out slow
That it's one thing to try and another to fly
You get there quicker just a step at a time
It's one thing to bark, another to bite
The show ain't over till you pack up at night


Extras: Filter Print Post Top
OfflineStromriderM
This must be the place
Male User Gallery


Registered: 06/02/13
Posts: 7,336
Loc: Dept of know what I'm say... Flag
Last seen: 11 hours, 34 minutes
Trusted Cultivator
Re: DIY Dehydrator setup [Re: rumfor69]
    #26579749 - 04/05/20 03:17 PM (3 years, 10 months ago)

Quote:

rumfor69 said:
What's the warranty and life length of those Cabelas dehydrators and
are they fairly quiet?




They're pretty quiet for what they are. Pirate would be the one to ask about longevity. He's been using them for many years. I've only started using them about a year ago. I know pirate has some that are several years old and you know he runs the piss out of them so must be pretty solid

I know for sure you can't get parts for them though


Edited by Stromrider (04/05/20 03:18 PM)


Extras: Filter Print Post Top
InvisiblePiptheGreAtest
Aspiring Heavyweight
I'm a teapot User Gallery

Registered: 07/18/16
Posts: 464
Re: DIY Dehydrator setup [Re: filthyknees]
    #26579856 - 04/05/20 04:02 PM (3 years, 10 months ago)

Quote:

filthyknees said:
Hey pip,

How much exhaust and heat you need depends on your space, it won't be that hard to do. Gonna have to test it ultimately, - I used a bag of apples cut up before drying cubes (throw a lot of banana on there too.. for testing purposes).
For similar dimentions I used 2 1500w heaters, from the bottom, and a boxfan on low in the middle.

The exhaust is passive (think of a traditional common dehydrator). Anything above 100 will work, definitely no need to go above 160.

Also something to note, mine was located in an open air garage, in the winter and fall it worked fine but with the high humidity of summer I had to invest in another Cabela's because the fans where blowing air in with such a water content the mushrooms had no way to dry. Barring the high humidity environment sinario it worked well.

Based on madhatter420s build

Details here https://www.shroomery.org/forums/showflat.php/Number/25824371





Just to note that’s the exact build I’m modeling this after but building from scratch. I was entertaining the idea of buying one of those cabelas 160l but I figure this will fit more fruit and cheaper . So I suppose just lean towards putting two 1500watt on bottom if these are heater fans is the box fan necessary? For passive exhaust wouldn’t you have leave top unsealed I plan on using weather stripping and sealant to prevent temp differences in the box. I figure if I drill couple holes around top it will have better temp. control. Anything wrong with this reasoning?


--------------------


Extras: Filter Print Post Top
Invisiblefilthyknees
no coincidence
 User Gallery

Registered: 03/08/13
Posts: 6,283
Trusted Cultivator
Re: DIY Dehydrator setup [Re: PiptheGreAtest]
    #26579937 - 04/05/20 04:40 PM (3 years, 10 months ago)

That's fine, as long as you're cool with fruits on top trays taking a couple days to dry and having to rotate trays down. That's the downside to cost savings.

Less holes on top is better, I started off with four 1.5 in holes in the top and ended up plugging them all and using the small uninsulated crack between the frame and doors for exhaust.

My box fan was needed because the overheat saftey mechanism in the heaters would kick on without it on low.


--------------------
But if you're in a hurry, and really got to go
If you're in a hurry, might have to find out slow
That it's one thing to try and another to fly
You get there quicker just a step at a time
It's one thing to bark, another to bite
The show ain't over till you pack up at night


Extras: Filter Print Post Top
OfflineStromriderM
This must be the place
Male User Gallery


Registered: 06/02/13
Posts: 7,336
Loc: Dept of know what I'm say... Flag
Last seen: 11 hours, 34 minutes
Trusted Cultivator
Re: DIY Dehydrator setup [Re: filthyknees] * 1
    #26580041 - 04/05/20 05:28 PM (3 years, 10 months ago)

I will say those cabelas 160 liter dehydrators are beast. I can load that thing slam full and it's done in about 16 hours. There's something to be said for that. Probably quite a bit more power efficient. No rotating racks either. They changed the design a couple years ago. I have an old style and a new style. The new ones are way faster than the old style. The did well. They are expensive but it's just another drop in the bucket boys. Between 75x sterilizers, dehydrators, and lab equipment I have enough invested to get a new truck 😂
Takes money to make money


Edited by Stromrider (04/05/20 05:29 PM)


Extras: Filter Print Post Top
Onlinerumfor69
Bodhicitta Cultivator
Male


Registered: 08/05/11
Posts: 6,843
Loc: In the Gills
Last seen: 9 minutes, 24 seconds
Re: DIY Dehydrator setup [Re: Stromrider]
    #26580061 - 04/05/20 05:40 PM (3 years, 10 months ago)

Hellz yeah Stormrider I couldn't agree more and thanks for the info bro


--------------------

Links For Beginners And Beyond:mspoil:


Extras: Filter Print Post Top
Onlinerumfor69
Bodhicitta Cultivator
Male


Registered: 08/05/11
Posts: 6,843
Loc: In the Gills
Last seen: 9 minutes, 24 seconds
Re: DIY Dehydrator setup [Re: Stromrider]
    #26580063 - 04/05/20 05:41 PM (3 years, 10 months ago)

And good luck on your build Pip I hope you kick it's ass!


--------------------

Links For Beginners And Beyond:mspoil:


Extras: Filter Print Post Top
InvisiblePiptheGreAtest
Aspiring Heavyweight
I'm a teapot User Gallery

Registered: 07/18/16
Posts: 464
Re: DIY Dehydrator setup [Re: Stromrider]
    #26580112 - 04/05/20 06:03 PM (3 years, 10 months ago)

Quote:

filthyknees said:
That's fine, as long as you're cool with fruits on top trays taking a couple days to dry and having to rotate trays down. That's the downside to cost savings.

Less holes on top is better, I started off with four 1.5 in holes in the top and ended up plugging them all and using the small uninsulated crack between the frame and doors for exhaust.

My box fan was needed because the overheat saftey mechanism in the heaters would kick on without it on low.




So is the box fan facing heaters or dehydrator space?


Quote:

Stromrider said:
I will say those cabelas 160 liter dehydrators are beast. I can load that thing slam full and it's done in about 16 hours. There's something to be said for that. Probably quite a bit more power efficient. No rotating racks either. They changed the design a couple years ago. I have an old style and a new style. The new ones are way faster than the old style. The did well. They are expensive but it's just another drop in the bucket boys. Between 75x sterilizers, dehydrators, and lab equipment I have enough invested to get a new truck 😂
Takes money to make money




I hear you but I’d need like 3 of them, I’m running up to 42 monos. How much wet weight think one fits?


--------------------


Extras: Filter Print Post Top
OfflineStromriderM
This must be the place
Male User Gallery


Registered: 06/02/13
Posts: 7,336
Loc: Dept of know what I'm say... Flag
Last seen: 11 hours, 34 minutes
Trusted Cultivator
Re: DIY Dehydrator setup [Re: PiptheGreAtest]
    #26580152 - 04/05/20 06:17 PM (3 years, 10 months ago)

Are you spawning all 42 at once or like 10 a week?

1 cabelas dehydrator can handle about 80 tubs spawning about 20 tubs every week ime
You can cram a bunch of boomers in them things and get pretty much 2 loads a day through it


Extras: Filter Print Post Top
Invisiblefilthyknees
no coincidence
 User Gallery

Registered: 03/08/13
Posts: 6,283
Trusted Cultivator
Re: DIY Dehydrator setup [Re: Stromrider]
    #26580191 - 04/05/20 06:34 PM (3 years, 10 months ago)

My box fan was facing upwards.

Cabela's will fit about 1.5-2# dry every 24 hours.

I think that big dehydrator came out to like .3#/shelf dry. But took longer.

So you'll have a larger capacity volumetrically, but if it takes twice as long is it as valuable.

Up to you.


--------------------
But if you're in a hurry, and really got to go
If you're in a hurry, might have to find out slow
That it's one thing to try and another to fly
You get there quicker just a step at a time
It's one thing to bark, another to bite
The show ain't over till you pack up at night


Extras: Filter Print Post Top
OnlineA.k.aM
Stranger
 User Gallery


Registered: 10/27/19
Posts: 16,816
Loc: Gaming the system
Last seen: 6 seconds
Trusted Cultivator
Re: DIY Dehydrator setup [Re: filthyknees] * 1
    #26580207 - 04/05/20 06:43 PM (3 years, 10 months ago)

Anybody ever tried to build some sort of cement tumbler with heat type contraption??


--------------------
LAGM2020


Extras: Filter Print Post Top
InvisiblePiptheGreAtest
Aspiring Heavyweight
I'm a teapot User Gallery

Registered: 07/18/16
Posts: 464
Re: DIY Dehydrator setup [Re: Stromrider]
    #26580473 - 04/05/20 08:52 PM (3 years, 10 months ago)

Quote:

Stromrider said:
Are you spawning all 42 at once or like 10 a week?

1 cabelas dehydrator can handle about 80 tubs spawning about 20 tubs every week ime
You can cram a bunch of boomers in them things and get pretty much 2 loads a day through it



42 all at once. Dam that is my kind of machine. Sounds like it will work for me, guys shifted my opinion I’m getting one.


--------------------


Extras: Filter Print Post Top
OfflineSloppyJoseph
Non-sporalator
Male User Gallery

Registered: 12/08/15
Posts: 8,511
Last seen: 3 years, 8 months
Re: DIY Dehydrator setup [Re: Stromrider]
    #26580580 - 04/05/20 09:36 PM (3 years, 10 months ago)

Quote:

Stromrider said:
I will say those cabelas 160 liter dehydrators are beast. I can load that thing slam full and it's done in about 16 hours. There's something to be said for that. Probably quite a bit more power efficient. No rotating racks either. They changed the design a couple years ago. I have an old style and a new style. The new ones are way faster than the old style. The did well. They are expensive but it's just another drop in the bucket boys. Between 75x sterilizers, dehydrators, and lab equipment I have enough invested to get a new truck 😂
Takes money to make money




How much dry comes out of that thing packed tight?


--------------------
AMU Q&A


Extras: Filter Print Post Top
OfflineLogicaL ChaosM
Ascension Energy & Alien UFOs
Male User Gallery


Folding@home Statistics
Registered: 05/12/07
Posts: 69,599
Loc: The Inexpressible... Flag
Last seen: 2 hours, 20 minutes
Trusted Cultivator
Re: DIY Dehydrator setup [Re: A.k.a]
    #26580644 - 04/05/20 10:10 PM (3 years, 10 months ago)

Quote:

A.k.a said:
Anybody ever tried to build some sort of cement tumbler with heat type contraption??




Like a rotary drier, similar to large industrial clothes driers?


Extras: Filter Print Post Top
Jump to top Pages: 1 | 2 | Next >  [ show all ]

Shop: North Spore Cultivation Supplies   Kraken Kratom Red Vein Kratom   PhytoExtractum Maeng Da Thai Kratom Leaf Powder   Left Coast Kratom Buy Kratom Extract


Similar ThreadsPosterViewsRepliesLast post
* How does this setup look? BallsDeep 922 5 10/18/06 05:00 AM
by BallsDeep
* Advice need on exhaust problem Rahz 518 3 11/13/06 06:06 PM
by Rahz
* Re: Pics of my aquarium setup Anonymous 1,467 11 07/06/00 03:06 PM
by Gadget
* Dehydrator Project Cornelius 6,532 14 09/27/04 12:08 PM
by hyphae
* First time using a two tub setup woopka 733 1 02/28/07 04:44 PM
by farva86
* humidification/Air Exchange Setup. Phychotron 1,216 13 03/14/03 11:59 AM
by Alien
* looking for an opinion on my planned setup McNewbie 709 5 02/10/05 09:43 AM
by McNewbie
* Tips for setups with Ultrasonic + Coolmist
( 1 2 all )
exan 9,535 27 11/09/09 10:29 AM
by dopper dry

Extra information
You cannot start new topics / You cannot reply to topics
HTML is disabled / BBCode is enabled
Moderator: Shroomism, george castanza, RogerRabbit, veggie, mushboy, fahtster, LogicaL Chaos, 13shrooms, Stipe-n Cap, Pastywhyte, bodhisatta, Tormato, Land Trout, A.k.a
580 topic views. 36 members, 152 guests and 33 web crawlers are browsing this forum.
[ Show Images Only | Sort by Score | Print Topic ]
Search this thread:

Copyright 1997-2024 Mind Media. Some rights reserved.

Generated in 0.027 seconds spending 0.006 seconds on 14 queries.